THE USE OF SEWAGE SLUDGE AND ITS ASH IN CONSTRUCTION AND AGRICULTURE INDUSTRY: A REVIEW

Authors

  • Mohd Amin Shafii Centre of Geotechnics, Faculty of Engineering and The Built Environment, SEGi University, Kota Damansara, 47810 Petaling Jaya, Selangor, Malaysia
  • Eunice Chia Mei Ling Centre of Geotechnics, Faculty of Engineering and The Built Environment, SEGi University, Kota Damansara, 47810 Petaling Jaya, Selangor, Malaysia
  • Ekarizan Shaffie Institute of Infrastructure Engineering and Sustainable Management (IIESM), Faculty of Civil Engineering, Universiti Teknologi MARA, 40450 Shah Alam, Malaysia

DOI:

https://doi.org/10.11113/jt.v81.13486

Keywords:

Waste, sewage sludge, ash, disposal, reused

Abstract

Harmful sewage sludge generated from wastewater treatment plant being disposed to landfill has long caused major anxiety in local municipalities around the world. In line with the concept of sustainable development practice being adopted around the world, more efforts has looked deeper into ways to reuse this waste material and one of it was the ash generated from this material. This paper review the use of sewage sludge and sewage sludge ash (SSA) in construction and agriculture industry through a multi-faceted review of previous researches done in various industries. Besides reducing the amount of waste in landfill, this solution can also contribute to the reduction of natural resources consumption. It examines in detail how the various burning temperature can affect the sewage sludge ash as well as the potential usage of this ash in asphalt, concrete and cement mixture, soil stabilization and agriculture either as a substitute material, or as a raw and enhancement material. The various chemical composition in this ash enable the SSA to be used in application in multiple industry as each of the respective chemical composition bring enhancement to the end product respectively.

Author Biography

  • Mohd Amin Shafii, Centre of Geotechnics, Faculty of Engineering and The Built Environment, SEGi University, Kota Damansara, 47810 Petaling Jaya, Selangor, Malaysia
    Faculty of Engineering and The Built Environment, SEGi University, Kota Damansara, 47810 Petaling Jaya, Selangor, Malaysia

References

Antonio, J. T. A., Jose, M. S. and Artemio, C. 2015: Using Sewage-sludge Ash as Filler in Bituminous Mixes. Journal of Materials in Civil Engineering. 27[4]: 1-9.

DOI: https://doi.org/10.1061/(ASCE)MT.1943-5533.0001087.

Ing, J. C., Kuen, S. W., Ching, H. C. and Ya, T. L. 2006. Lightweight Aggregate Made from Sewage Sludge and Incinerated Ash. Waste Management. 26[12]: 1453-1461.

DOI: https://doi.org/10.1016/j.wasman.2005.11.024.

Sato, Y., Oyamada, T. and Hanahera, S. 2013. Applicability of Sewage Sludge Ash (SSA) for Paving Materials: A Study on using SSA as Filler for Asphalt Mixture and Base Course Material. Proceedings of the Third International Conference on Sustainable Construction Materials and Technologies.

DOI: www.claisse.info/2013%20papers/data/e283.pdf.

EUROSTAT. 2005. http://epp.eurostat.cec.eu.int.

Indah Water Konsortium Sdn Bhd. 2010. A Potty History of Sewage Sludge and it Treatment (Pamphlet).

Doh, S. I., Siew, C. C., Tan, K. G. and Adilen, S. 2016. The Use of Sewage Sludge Ash (SSA) As Partial Replacement of Cement in Concrete. ARPN Journal of Engineering and Applied Sciences. 11(6): 3771-3775.

DOI:http://www.arpnjournals.org/jeas/research_papers/rp_2016/jeas_0316_3877.pdf.

Leda, C. F. L. L., Jose, F. T. J., Jorge, B. S. and Manoel, G. P. 2014. Potential Uses of Sewage Sludge in Highway Construction. Journal of Materials in Civil Engineering. 27[4]: 1-7. DOI: 10.1061/(ASCE)MT.1943-5533.0000937.

Deepak, P., Yong, C. S., Jeong, H. K. and Ha, N. J. 2013. Fate and Behavior of Selected Heavy Metals with Mercury Mass Distribution in a Fluidized Bed Sewage Sludge Incinerator. Journal of Material Cycles and Waste Management. 15: 202-209. DOI: 10.1007/s10163-013-0115-z.

Ciaran, J. L., Ravindra, K. D., Gurmel, S. G. and Roger, P. W. 2015. Sewage Sludge Ash Characteristics and Potential for Use in Concrete. Construction and Building Materials. 98: 767-779.

DOI: http://dx.doi.org/10.1016/j.conbuildmat.2015.08.122.

Perez, C. M., Baeza, F. B., Payab, J., Savala, J.M., Zornozaa, E., Borracherob, M. V. and Garces, P. 2014. Potential Use of Sewage Sludge Ash (SSA) as a Cement Replacement in Precast Concrete Blocks. Materiales de Construcción. 64(313): 1-7. DOI: http://dx.doi.org/10.3989/mc.2014.06312.

Kenichiro, I. and Tsutomu, U. 2016. Reduction of Hazardous Elements Contained in Sewage Sludge Incineration Ash. Journal of Material Cycles and Waste Management.

DOI: 10.1007/s10163-016-0520-1.

Siew, C. C., Doh, S. I., Andri, K., Yih, K. W. and Saffuan, W. A. 2016. Characterization of Sewage Sludge Ash (SSA) in Cement Mortar. ARPN Journal of Engineering and Applied Sciences. 11(4): 2242-2247.

DOI:http://www.arpnjournals.org/jeas/research_papers/rp_2016/jeas_0216_3633.pdf.

Marta, K. K. 2011. Application of SSA as Partial Replacement of Aggregate in Concrete. Polish Journal of Environmental Studies. 20(2): 365-370.

DOI:http://www.pjoes.com/Application-of-SSA-as-Partial Replacement-r-nof-Aggregate-in-Concrete,88567,0,2.html.

Franz, M. 2007. Phosphate Fertilizer from Sewage Sludge Ash (SSA). Waste Management. 28: 1809-1818.

DOI: 10.1016/j.wasman.2007.08.011.

Martyn, C., Marie, C. and Pierre, C. 2007. Technological and Environmental Behavior of Sewage Sludge Ash (SSA) in Cement-based Materials. Cement and Concrete Research. 37: 1278-1289. DOI: 10.1016/j.cemconres.2007.04.003.

Kartini, K., Dahlia, L. A.M., Dayang, S. Q. A. A., Anthony, A.D., Nuraini, T. and Siti, R. R. 2015. Incinerated Domestic Waste Sludge Powder as Sustainable Replacement Material for Concrete. Pertanika Journal of Science and Technology. 23(2): 193-205.

DOI:http://www.pertanika.upm.edu.my/Pertanika%20PAPERS/JST%20Vol.%2023%20(2)%20Jul.%202015/04%20JST-0464-2013%20Rev1.pdf.

Lin D. F., Luo H. L. and Sheen Y. N. 2005. Glazed Tiles Manufactured from Incinerated Sewage Sludge Ash and Clay. Journal of the Air and Waste Management Association. 55: 163-172.

DOI: http://dx.doi.org/10.1080/10473289.2005.10464614.

Munjed, M. A. S. and Mousa, F. A. 2014. A Geoenvironmental Application of Burned Wastewater Sludge Ash in Soil Stabilization. Environmental Earth Science. 71: 2453-2463. DOI: 10.1007/s12665-013-2645-z.

Monzo, J., Paya, J., Borrachero, M. V. and Girbes, I. 2003. Reuse of Sewage Sludge Ashes (SSA) in Cement Mixtures: the Effect of SSA on the Workability of Cement Mortars. Waste Management. 23: 373-381. DOI: 10.1016/S0956-053X(03)00034-5.

Lin, D. F. and Weng, C. H. 2001. Use of Sewage Sludge Ash As Brick Material. Journal of Environmental Engineering. 127(10): 922-927. DOI:https://doi.org/10.1061/(ASCE)0733-9372(2001)127:10(922).

Lin, D. F., Luo, H. L., Hsiao, D. H., Chen, C. T. and Cai, M. D. 2016. Enhancing Soft Subgrade Soil with a Sewage Sludge Ash/Cement Mixture and Nano-Silicon Dioxide. Environmental Earth Sciences. 75(619): 1-13.

DOI: 10.1007/s12665-016-5432-9.

Tashima, M. M., Reig, L., Santini Jr, M. A., Moraes, J. C. B., Akasaki, J. L., Paya, J., Borrachero, M. V. and Soriano, L. 2017. Compressive Strength and Microstructure of Alkali-Activated Blast Furnace Slag/Sewage Sludge Ash (GGBS/SSA) Blends Cured at Room Temperature. Waste Biomass Valorization. 8(5): 1441-1451.

DOI: 10.1007/s12649-016-9659-1.

Georg, S., Harald, W., Clemens, M., Wilfried, W. and Bernd, H. 2010. Electrokinetic Phosphorus Recovery from Packed Beds of Sewage Sludge Ash: Yield and Energy Demand. Journal of Applied Electrochemistry. 40(6): 1069-1078.

DOI: 10.1007/s10800-009-0061-6.

Ewelina, K. 2014. Sewage Sludge Ash as an Alternative Low-cost Oxygen Carrier for Chemical Looping Combustion. Journal of Thermal Analysis and Calorimetry. 116(3): 1395-1407.

DOI: 10.1007/s10973-013-3564-7.

Lin, D. F., Lin, K. L. and Luo, H. L. 2007. A Comparison between Sludge Ash and Fly Ash on the Improvement in Soft Soil. Journal of the Air and Waste Management Association. 57: 59-64.

DOI: http://dx.doi.org/10.1080/10473289.2007.10465294.

Ziad, G., Taisir, K. and Alaa, G. 2008. Pollution Reduction and Reuse of Sludge Waste in Asphalt Paving Mixtures. 12th International Conference on Integrated Diffuse Pollution Management (IWA DIPCON). Khon Kaen University, Thailand.

Khyati, S., Alan, N., Ryan, W., and Aaron, N., Prashant, S., and Yusuf, M., Kauser, J. and Christopher, T. 2009. Evaluation of Sewage Sludge Ash in Asphalt Concrete Using Disk-Shaped Compact Tension Testing. Proceedings of the Water Environment Federation. 7491-7495.

DOI: 10.2175/193864709793900159.

Hainin, M. R., Jaya, R. P., Akbar, N. A. A., Jayanti, D. S. and Yusoff, N. I. M. 2014. Influence of POFA as a Modifer on Bitumen to Improve Aging Resistance. Journal of Engineering Research. 2(1): 33-46.

Habeeb, G. A. and Mahmud, H. 2010. Study on Properties of Rice Husk Ash and Its Use as Cement Replacement Material. Materials Research. 13(2): 185-190.

DOI: 10.1590/S1516-14392010000200011.

Rajesh, S. G. and Krupesh, A. C. 2013. Feasibility of Rice Husk Ash as Optional Mineral Filler in Microsurfacing incorporating Type III Aggregate. American Journal of Environmental Engineering. 3(2): 95-99. DOI: 10.5923/j.ajee.20130302.02.

Sobolev, K., Vivian, I. F., Bohler, J. D., Faheem, A. and Covi, A. 2013. Application of Fly Ash in Ashphalt Concrete: From Challenges to Opportunities. World of Coal Ash Conference. Lexington.

Al Sayed, M. H., Madany, I. M. and Buali, A. R. M. 1995. Use of Sewage Sludge Ash in Asphaltic Paving Mixes in Hot Regions. Construction and Building Materials. 9(1): 19-23.

DOI: https://doi.org/10.1016/0950-0618(95)92856-C.

Zachary, G. A. and Donald, O. 2016. Suitability of Sewage Sludge Ash as a Filler Material in Asphalt Concrete. Journal of Multidisciplinary Engineering Science Studies. 2(3): 322-331.

Jakarni, F. M., Yusoff, N. I. M., Wu, J. and Aziz, M. M. A. 2015. Utilization of Sewage Sludge Molten Slag as Aggregate Substitute in Asphalt Mixtures. Jurnal Teknologi. 73(4): 105-110. DOI: 10.11113/jt.v73.4302.

Piasta, W. and Lukawska, M. 2016. The Effect of Sewage Sludge Ash on Properties of Cement Composites. World Multidisciplinary Civil Engineering-Architecture-Urban Planning Symposium. 161: 1018-1024.

DOI: 10.1016/j.proeng.2016.08.842.

Gullu, H. and Girisken, S. 2013. Performance of Fine-grained Soil Treated with Industrial Wastewater Sludge. Environmental Earth Sciences. 70[2]: 777-788.

DOI: 10.1007/s12665-012-2167-0.

Chen, L. and Lin, D. F. 2009. Stabilization Treatment of Soft Subgrade Soil by Sewage Sludge Ash and Cement. Journal of Hazardous Materials. 162 (1): 321-327.

DOI: 10.1016/j.jhazmat.2008.05.060.

Luo, H. L., Hsiao, D. H., Lin, D. F. and Lin, C. K. 2012. Cohesive Soil Stabilized Using Sewage Sludge Ash/Cement and Nano Aluminum Oxide. International Journal of Transportation Science and Technology. 1(1): 83-100.

Lin, D. F., Lin, K. L., Hung, M. J. and Luo, H. L. 2007. Sludge Ash/hydrated Lime on the Geotechnical Properties of Soft Soil. Journal of Hazardous Materials. 145: 58-64.

DOI: 10.1016/j.jhazmat.2006.10.087.

Hossain, M. L., Salam, M. A., Rubaiyat, A. and Hossain, M. K. 2013. Sewage Sludge as Fertilizer on Seed Germination and Seedling Growth: Safe or Harm. International Journal of Research in Management. 2(3): 136-146.

Sohaili, J., Zaidi, N. S. and Seng, C. L. 2012. Nutrients Content of Sewage Sludge and Its Utilization Towards Horticulture Plant. Journal of Emerging Trends in Engineering and Applied Sciences. 3[1]: 81-85.

DOI: http://dx.doi.org/10.1063/1.4928860.

Lazdina, D., Lazdins, A., Karins, Z. and Kaposts, V. 2007. Effect of Sewage Sludge Fertilization in Short-rotation Willow Plantations. Journal of Environmental Engineering and Landscape Management. 15(2): 105-111.

DOI: http://dx.doi.org/10.1080/16486897.2007.9636916.

Hughes, J. C., Noble, A. D. and Scott, B. S. 1993. The Use of Sewage Sludge as a Fertilizer for Wheat in a Glasshouse Pot Experiment. South African Journal of Plant and Soil. 10[2]: 85-90.

DOI: http://dx.doi.org/10.1080/02571862.1993.10634649.

Downloads

Published

2019-08-19

Issue

Vol. 81 No. 5: September 2019

Section

Science and Engineering

License

Copyright of articles that appear in Jurnal Teknologi belongs exclusively to Penerbit Universiti Teknologi Malaysia (Penerbit UTM Press). This copyright covers the rights to reproduce the article, including reprints, electronic reproductions, or any other reproductions of similar nature.

How to Cite

THE USE OF SEWAGE SLUDGE AND ITS ASH IN CONSTRUCTION AND AGRICULTURE INDUSTRY: A REVIEW. (2019). Jurnal Teknologi, 81(5). https://doi.org/10.11113/jt.v81.13486