PERFORMANCE AND EMISSIONS OF DUAL ALCOHOL FUEL BLEND WITH B20 POME BIODIESEL IN DIESEL ENGINE

Authors

  • Asiah Ab. Rahim School of Mechanical Engineering, College of Engineering, Universiti Teknologi MARA, 23200 Bukit Besi, Terengganu, Malaysia
  • Idris Saad School of Mechanical Engineering, College of Engineering, Universiti Teknologi MARA, 40450 Shah Alam, Selangor, Malaysia
  • Nurin Wahidah Mohd Zulkifli Department of Mechanical Engineering, Faculty of Engineering, Universiti Malaya, 50603 Kuala Lumpur, Malaysia
  • Mohd Nur Ashraf Mohd Yusoff Department of Mechanical Engineering, Faculty of Engineering, Universiti Malaya, 50603 Kuala Lumpur, Malaysia

DOI:

https://doi.org/10.11113/jurnalteknologi.v87.21791

Keywords:

Dual alcohol, Pentanol, ethanol, B20 POME biodiesel, diesel engine

Abstract

Biodiesel-diesel blends are known to result in increased NOx emissions compared to diesel alone, while ethanol as a ternary fuel in diesel-biodiesel shows that the blend successfully lowers diesel fuel NOx emissions but increases BSFC consumption. Hypothetically, pentanol, when added to blends as a second alcohol, may enhance engine performance and lower NOx emissions because pentanol exhibits superior characteristics including cetane number (CN) and viscosity, which is closer to diesel, as well as a higher calorific value. Therefore, this research aims to investigate engine performance and exhaust emission diesel engine operating with dual alcohol (ethanol and pentanol) +B20 POME biodiesel blend. The experiments involved evaluating different engine loads (25%, 50%, and 75%) at a constant speed of 1800 RPM. The findings indicate that the BSFC of dual alcohol blends are higher than diesel and B20 for all tested loads, with B20E10P10 showing least increment by 6.56% and 11.18% respectively. At 75% engine load, B20E10P30 exhibits a higher BTE by 2.11% compared to Diesel. The addition of dual alcohol in the blend significantly reduces NOx emissions, especially with B20E10P30. CO₂ emissions from B20E10P30 are closer to diesel fuel and B20, being only 1.54% lower than diesel and 0.79% higher than B20 at lower engine loads. For CO emissions, B20E10P10 shows the lowest CO emissions compared to B20E10P20 and B10E10P30. The findings suggest that combining higher alcohol with lower alcohol can effectively enhance the overall performance and emission characteristics of the fuel blend, supporting the hypothesis above.

References

M. S. N. Awang et al. 2021. Effect of Addition of Palm Oil Biodiesel in Waste Plastic Oil on Diesel Engine Performance, Emission, and Lubricity. ACS Omega. 6(33): 21655–21675. Doi: 10.1021/acsomega.1c03073.

H. Hosseinzadeh-Bandbafha, M. Tabatabaei, M. Aghbashlo, M. Khanali, and A. Demirbas. 2018. A Comprehensive Review on the Environmental Impacts of Diesel/biodiesel Additives. Energy Convers. Manag. 174(August): 579–614. Doi: 10.1016/j.enconman.2018.08.050.

M. M. Musthafa, T. A. Kumar, T. Mohanraj, and R. Chandramouli. 2018. A Comparative Study on Performance, Combustion and Emission Characteristics of Diesel Engine Fuelled by Biodiesel Blends with and Without an Additive. Fuel. 225(March): 343–348. Doi: 10.1016/j.fuel.2018.03.147.

I. M. Monirul et al. 2016. Assessment of Performance, Emission and Combustion Characteristics of Palm, Jatropha and Calophyllum Inophyllum Biodiesel Blends. Fuel. 181: 985–995. Doi: 10.1016/j.fuel.2016.05.010.

A. Nalgundwar, B. Paul, and S. Kumar. 2017. Comparison of Performance and Emissions Characteristics of DI CI Engine Fueled with Dual Biodiesel Blends of Palm and Jatropha. Fuel. 173(2016): 172–179. Doi: 10.1016/j.fuel.2016.01.022.

M. S. Gad, R. El-araby, K. A. Abed, N. N. El-ibiari, A. K. El Morsi, and G. I. El-diwani. 2018. Performance and Emissions Characteristics of C. I. Engine Fueled with Palm Oil/Palm Oil Methyl Ester Blended with Diesel Fuel. Egypt. J. Pet. 27(2): 215–219. Doi: 10.1016/j.ejpe.2017.05.009.

K. Fangsuwannarak, P. Wanriko, and T. Fangsuwannarak. 2016. Effect of Bio-polymer Additive on the Fuel Properties of Palm Biodiesel and on Engine Performance Analysis and Exhaust Emission. Energy Procedia. 100(September): 227–236. Doi: 10.1016/j.egypro.2016.10.170.

O. M. Ali, T. Yusaf, R. Mamat, N. R. Abdullah, and A. A. Abdullah. 2014. Influence of Chemical Blends on Palm Oil Methyl Esters’ Cold Flow Properties and Fuel Characteristics. Energies. 4364–4380. Doi: 10.3390/en7074364.

M. P. O. C. (MPOC). 2020. Outlook of Malaysian Biodiesel Mandate in 2020. http://mpoc.org.my/outlook-of-malaysian-biodiesel-mandate-in-2020/ (accessed Jan. 28, 2020).

M. Hizami, M. Yuso, M. Ayoub, N. Jusoh, and A. Z. Abdullah. 2020. The Challenges of a Biodiesel Implementation Program in Malaysia. Processes. 8(1244): 1–18. Doi: 10.3390/pr8101244.

L. Zhu, C. S. Cheung, W. G. Zhang, and Z. Huang. 2010. Emissions Characteristics of a Diesel Engine Operating on Biodiesel and Biodiesel Blended with Ethanol and Methanol. Sci. Total Environ. 408(4): 914–921.

Doi: 10.1016/j.scitotenv.2009.10.078.

M. Mo, M. G. Rasul, J. Hyde, A. K. Azad, R. Mamat, and M. M. K. Bhuiya. 2016. Role of Biofuel and Their Binary (Diesel – Biodiesel) and Ternary (Ethanol – Biodiesel – Diesel) Blends on Internal Combustion Engines Emission Reduction. Renew. Sustain. Energy Rev. 53: 265–278.

Doi: 10.1016/j.rser.2015.08.046.

H. Aydin and C. Ilkiliç. 2010. Effect of Ethanol Blending with Biodiesel on Engine Performance and Exhaust Emissions in a CI Engine. Appl. Therm. Eng. 30(10): 1199–1204.

Doi: 10.1016/j.applthermaleng.2010.01.037.

H. V. Srikanth, S. G, B. Manne, and S. B. Kumar. 2021. Niger Seed Oil Biodiesel as an Emulsifier in Diesel-ethanol Blends for Compression Ignition Engine. Renew. Energy. 163: 1467–1478. Doi: 10.1016/j.renene.2020.07.010.

A. A. Rahim, N. Rosli, A. Mohamad, and H. Mazlan. 2021. Effect of Fuel Additives (Ethanol) on the Engine Performance Emissions of Single Cylinder Diesel Engine Fueled with Palm Oil Methyl Ester Effect of Fuel Additives (Ethanol) on the Engine Performance Emissions of Single Cylinder Diesel Engine Fueled wi. IOP Conf. Ser. Mater. Sci. Eng. 1062(012013): 1–8.

Doi: 10.1088/1757-899X/1062/1/012013.

S. K. Kandasamy, A. S. Selvaraj, and T. K. R. Rajagopal. 2019. Experimental Investigations of Ethanol Blended Biodiesel Fuel on Automotive Diesel Engine Performance, Emission and Durability Characteristics. Renew. Energy. 141: 411–419. Doi: 10.1016/j.renene.2019.04.039.

N. Yilmaz, A. Atmanli, and F. M. Vigil. 2018. Quaternary Blends of Diesel, Biodiesel, Higher Alcohols and Vegetable Oil in a Compression Ignition Engine. Fuel. 212(October): 462–469. Doi: 10.1016/j.fuel.2017.10.050.

P. Appavu, V. Ramanan M, and H. Venu. 2019. Quaternary Blends of Diesel/biodiesel/vegetable oil/pentanol as a Potential Alternative Feedstock for Existing Unmodified Diesel Engine: Performance, Combustion and Emission Characteristics. Energy. 186: 115856. Doi: 10.1016/j.energy.2019.115856.

H. K. Imdadul et al. 2016. Influences of Ignition Improver Additive on Ternary (Diesel-biodiesel-higher Alcohol) Blends Thermal Stability and Diesel Engine Performance. Energy Convers. Manag. 123: 252–264.

Doi: 10.1016/j.enconman.2016.06.040.

Q. Wang, S. Yin, and J. Ni. 2021. The Effects of n-pentanol, di-n-butyl Ether (DBE) and Exhaust Gas Recirculation on Performance and Emissions in a Compression Ignition Engine. Fuel. 284(August): 118961.

Doi: 10.1016/j.fuel.2020.118961.

A. Atmanli and N. Yilmaz. 2020. An Experimental Assessment on Semi-low Temperature Combustion using Waste Oil Biodiesel/C3-C5 Alcohol Blends in a Diesel Engine. Fuel. 260(September): 116357.

Doi: 10.1016/j.fuel.2019.116357.

C. Jin et al. 2019. Effects of C3–C5 Alcohols on Solubility of Alcohols/diesel blends. Fuel. 236(April): 65–74.

Doi: 10.1016/j.fuel.2018.08.129.

J. Liang, Q. Zhang, Q. Ma, Z. Chen, and Z. Zheng. 2022. Effect of Various Ethanol/diesel Cosolvents Addition on Combustion and Emission Characteristics of a CRDI Heavy Diesel Engine. Energy Reports. 8: 735–748.

Doi: 10.1016/j.egyr.2021.12.011.

H. Liu, B. Hu, and C. Jin. 2016. Effects of Different Alcohols Additives on Solubility of Hydrous Ethanol/diesel Fuel Blends. Fuel. 184: 440–448. Doi: 10.1016/j.fuel.2016.07.037.

M. K. Yesilyurt. 2020. A Detailed Investigation on the Performance, Combustion, and Exhaust Emission Characteristics of a Diesel Engine Running on the Blend of Diesel Fuel, Biodiesel and 1-heptanol (C7 alcohol) as a Next-generation Higher Alcohol. Fuel. 275.

F. Yan et al. 2023. Experimental Investigation of the Two-Stage Ignition Delay and Flame Structure of Pentanol/n-dodecane Binary Fuel. Energy. 262(PB): 125546. Doi: 10.1016/j.energy.2022.125546.

J. P. Holman. 1994. Experimental Methods for Engineers. 6th ed. McGraw Hill. Inc.

I. Örs, S. Sar, A. E. Atabani, S. Ünalan, and S. O. Akansu. 2018. The Effects on Performance, Combustion and Emission Characteristics of DICI Engine Fuelled with TiO2 Nanoparticles Addition in Diesel/biodiesel/n-butanol Blends. 234(July): 177–188. Doi: 10.1016/j.fuel.2018.07.024.

A. Ramesh, B. Ashok, K. Nanthagopal, M. R. Pathy, and A. Tambare. 2019. Influence of Hexanol as Additive with Calophyllum Inophyllum Biodiesel for CI Engine Applications. Fuel. 249: 472–485.

Doi: 10.1016/j.fuel.2019.03.072.

N. Yilmaz and A. Atmanli. 2017. Experimental Assessment of a Diesel Engine Fueled with Diesel-biodiesel-1-pentanol Blends. Fuel. 191: 190–197. Doi: 10.1016/j.fuel.2016.11.065.

A. Atmanli and N. Yilmaz. 2018. A Comparative Analysis of n-butanol/diesel and 1-pentanol/diesel Blends in a Compression Ignition Engine. Fuel. 234(May): 161–169.

Doi: 10.1016/j.fuel.2018.07.015.

H. K. Imdadul et al. 2016. Higher Alcohol-biodiesel-diesel Blends: An Approach for Improving the Performance, Emission, and Combustion of a Light-duty Diesel Engine. Energy Convers. Manag. 111: 174–185.

Doi: 10.1016/j.enconman.2015.12.066.

O. M. Ali, R. Mamat, N. R. Abdullah, and A. Adam. 2016. Analysis of Blended Fuel Properties and Engine Performance with palm Biodiesel e Diesel Blended Fuel. Renew. Energy. 86: 59–67.

Doi: 10.1016/j.renene.2015.07.103.

N. Yilmaz and A. Atmanli. 2017. Experimental Evaluation of a Diesel Engine Running on the Blends of Diesel and Pentanol as a Next Generation Higher Alcohol. Fuel. 210(June): 75–82. Doi: 10.1016/j.fuel.2017.08.051.

M. Karabektas and Y. M. Sabit. 2022. Investigation of the Effects of High-carbon Alcohol Addition to Camelina Oil Methyl Ester on the Performance Parameters and Soot Emission of a Diesel Engine. Int. J. Low-Carbon Technol. 17(January): 206–213.

M. K. Yesilyurt, T. Eryilmaz, and M. Arslan. 2018. A Comparative Analysis of the Engine Performance, Exhaust Emissions and Combustion Behaviors of a Compression Ignition Engine Fuelled with Biodiesel/diesel/1-butanol (C4 alcohol) and Biodiesel/diesel/n-pentanol (C5 alcohol) Fuel Blends. Energy. 165: 1332–1351.

Doi: 10.1016/j.energy.2018.10.100.

A. Atmanli and N. Yilmaz. 2020. An Experimental Assessment on Semi-low Temperature Combustion using waste Oil Biodiesel/C3-C5 Alcohol Blends in a Diesel Engine. Fuel. 260(July). Doi: 10.1016/j.fuel.2019.116357.

N. Yilmaz, A. Atmanli, and M. Trujillo. 2017. Influence of 1-Pentanol Additive on the Performance of a Diesel Engine Fueled with Waste Oil Methyl Ester and Diesel Fuel. Fuel. 207: 461–469. Doi: 10.1016/j.fuel.2017.06.093.

A. Atmanli. 2016. Comparative Analyses of Diesel – waste Oil Biodiesel and Propanol, n-butanol or 1-pentanol Blends in a Diesel Engine. Fuel. 176: 209–215.

Doi: 10.1016/j.fuel.2016.02.076.

M. V. De Poures et al. 2020. Comparative Account of the Effects of Two High Carbon Alcohols (C5 & C6) on Combustion, Performance and Emission Characteristics of a DI Diesel Engine. Energy Sources, Part A Recover. Util. Environ. Eff. 42(14): 1772–1784.

Doi: 10.1080/15567036.2019.1604888.

M. Nour, A. M. A. Attia, and S. A. Nada. 2019. Improvement of CI Engine Combustion and Performance Running on Ternary Blends of Higher Alcohol (Pentanol and Octanol)/hydrous ethanol/diesel. Fuel. 251(December): 10–22. Doi: 10.1016/j.fuel.2019.04.026.

A. Prabhu, M. V. Ramanan, N. Joy, M. Anudeep, B. Srikanth, and H. Venu. 2020. Emission Study for Pentanol and Pongamia Biodiesel Blends in a di Diesel Engine. AIP Conf. Proc. 2311(December). Doi: 10.1063/5.0034067.

J. Jeevahan, S. Lakshmi Sankar, P. Karthikeyan, V. Sriram, and G. Britto Joseph. 2020. Comparative Investigation of the Effects of Lower and Higher Alcohols/bio-diesel Blends on Engine Performance and Emissions Characteristics of a Diesel Engine. Int. J. Ambient Energy. 41(6): 652–658.

Doi: 10.1080/01430750.2018.1484809.

Z. Abdullah, A. Abdullah, H. Suhaimi, and M. Akmal. 2019. Impact of Diesel-biodiesel-hexanol Tri-fuel Blends on the Combustion and Exhaust Emissions Characteristics of a Diesel Engine. IOP Conf. Ser. Mater. Sci. Eng. 469(1).

Doi: 10.1088/1757-899X/469/1/012043.

A. Atmanli, E. Ileri, B. Yuksel, and N. Yilmaz. 2015. Extensive Analyses of Diesel-vegetable oil-n-butanol Ternary Blends in a Diesel Engine. Appl. Energy. 145: 155–162.

Doi: 10.1016/j.apenergy.2015.01.071.

M. K. Yesilyurt, M. Aydin, Z. Yilbasi, and M. Arslan. 2020. Investigation on the Structural Effects of the Addition of Alcohols Having Various Chain Lengths into the Vegetable Oil-biodiesel-diesel Fuel Blends: An Attempt for Improving the Performance, Combustion, and Exhaust Emission Characteristics of a Compressi. Fuel. 269(January): 117455. Doi: 10.1016/j.fuel.2020.117455.

L. Konjević, M. Racar, P. Ilinčić, and F. Faraguna. 2023. A Comprehensive Study on Application Properties of Diesel Blends with Propanol, Butanol, Isobutanol, Pentanol, Hexanol, Octanol and Dodecanol. Energy. 262(April).

Doi: 10.1016/j.energy.2022.125430.

Published

2025-03-12

Issue

Section

Science and Engineering

How to Cite

PERFORMANCE AND EMISSIONS OF DUAL ALCOHOL FUEL BLEND WITH B20 POME BIODIESEL IN DIESEL ENGINE. (2025). Jurnal Teknologi (Sciences & Engineering), 87(3). https://doi.org/10.11113/jurnalteknologi.v87.21791