OPTIMIZATION OF NON THERMAL PLASMA REACTOR PERFORMANCE FOR THE DECOMPOSITION OF XYLENE

Authors

  • Nor Faraliana Shazwani Nor Azmi Department of Chemical Engineering, Faculty of Chemical Engineering, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia
  • Abdullahi Mohammed Evuti Department of Chemical Engineering, Faculty of Chemical Engineering, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia
  • Mohd Ariffin Abu Hassan Institute of Environmental and Water Resources Management, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia
  • R. K. Raja Ibrahim Advanced Photonic Science Institute, Physics Department, Faculty of Science, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia

DOI:

https://doi.org/10.11113/jt.v78.7595

Keywords:

Xylene, non-thermal plasma, optimization, response surface methodology, wastewater, SS (Sums of Square), MS (Mean square), DF (Degree of Freedom)

Abstract

Non Thermal Plasma (NTP) is an emerging method used for the decomposition of volatile organic compounds (VOCs). This research focuses on the optimization of NTP reactor performance for decomposition of xylene from wastewater using response surface methodology (RSM) by operating the NTP reactor at applied voltage of 12-15 kV, discharge gap of 2.0-3.0 cm and gas flow rate of 2.0-5.0 L/min. An optimum xylene removal efficiency of 81.98% was obtained at applied voltage 15kV, discharge gap 2.09cm and gas flow rate at 2.36 L/min. The experimental removal efficiencies and model predictions were in close agreement with an error of 0.63%.

 

Author Biographies

  • Nor Faraliana Shazwani Nor Azmi, Department of Chemical Engineering, Faculty of Chemical Engineering, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia

    1. Department of Chemical Engineering, Faculty of Chemical Engineering

  • Mohd Ariffin Abu Hassan, Institute of Environmental and Water Resources Management, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia

    1. Department of Chemical Engineering, Faculty of Chemical Engineering

    2. Institute of Environmental and Water Resources Management

  • R. K. Raja Ibrahim, Advanced Photonic Science Institute, Physics Department, Faculty of Science, Universiti Teknologi Malaysia, 81310 UTM Johor Bahru, Johor, Malaysia
    3. Advanced Photonic Science Institute, Physics Department, Faculty of Science

References

Wijmans, J., Kamaruddin, H., Segelke, S., Wessling, M. & Baker, R. 1997. Removal Of Dissolved Vocs From Water With An Air Stripper/Membrane Vapor Separation System. Separation Science and Technology. 32: 2267-2287.

Zhu, T., Li, J., Jin, Y., Liang, Y. & Ma, G. 2008. Decomposition Of Benzene By Non-Thermal Plasma Processing: Photocatalyst and Ozone Effect. Int. J. Environ. Sci. Tech. 5: 375-384.

Abd Allah, Z., Whitehead, J. C. & Martin, P. 2013. Remediation Of Dichloromethane (CH2Cl2) Using Non-Thermal, Atmospheric Pressure Plasma Generated in A Packed-Bed Reactor. Environmental Science & Technology.

Cal, M. P. & Schluep, M. 2001. Destruction of Benzene with Nonâ€Thermal Plasma in Dielectric Barrier Discharge Reactors. Environmental Progress. 20: 151-156.

Magureanu, M., Piroi, D., Mandache, N. B., David, V., Medvedovici, A. & Parvulescu, V. I. 2010. Degradation Of Pharmaceutical Compound Pentoxifylline In Water By Non-Thermal Plasma Treatment. Water Research. 44: 3445-3453.

Manoj Kumar Reddy, P., Rama Raju, B., Karuppiah, J., Linga Reddy, E. & Subrahmanyam, C. 2012. Degradation And Mineralization Of Methylene Blue By Dielectric Barrier Discharge Non-Thermal Plasma Reactor. Chemical Engineering Journal.

Karatum, O., Marc A, Deshusses. 2016. A Comparative Study of Dilute VOCs Treatment in a Non-Thermal Plasma reactor. Chemical Engineering Journal. 294 (2016): 308-315

Fitzsimmons, C., Ismail, F., Whitehead, J. & Wilman, J. 2000. The Chemistry of Dichloromethane Destruction In Atmospheric-Pressure Gas Streams By A Dielectric Packed-Bed Plasma Reactor. The Journal of Physical Chemistry A. 104: 6032-6038.

Chen, H. L., Lee, H. M., Chen, S. H. & Chang, M. B. 2008. Review of Packed-Bed Plasma Reactor For Ozone Generation And Air Pollution Control. Industrial & Engineering Chemistry Research. 47: 2122-2130.

Tang, X., Wang, M., Feng, W., Feng, F. & Yan, K. 2011. VOCs Degradation With Non-Thermal Plasma And Ag–Mnox Catalysis. International Symposium On Plasma Chemistry.

Ahmad, N. A., Hassan, M. A. A., Noor, Z. Z., Evuti, A. M. & Danlami, J. M. 2014. Optimization of Nickel Removal from Electroless Plating Industry Wastewater using Response Surface Methodology. Jurnal Teknologi. 67.

Ahmad, N. A., Hassan, M. A. A., Noor, Z. Z., Evuti, A. M. & Fairuz Juiani, S. 2013. Optimization of the Performance of Chitosan for the Nickel Removal from wastewater. World Applied Sciences Journal. 2: 1118-1124.

Dou, B., Li, J., Liang, W., Zhu, T., Li, Y., Jin, Y. & He, L. 2008. Volatile Organic Compounds (VOCs) Removal By Using Dielectric Barrier Discharge. Bioinformatics And Biomedical Engineering, The 2nd International Conference. IEEE. 3945-3948.

Lee, H. M. & Chang, M. B. 2003. Abatement Of Gas-Phase P-Xylene Via Dielectric Barrier Discharges. Plasma Chemistry And Plasma Processing. 23: 541-558.

Ozturk, B. & Yilmaz, D. 2006. Absorptive Removal Of Volatile Organic Compounds From Flue Gas Streams. Process Safety and Environmental Protection. 84: 391-398.

Andale. 2014. Sum of Squares: Residual Sum, Total Sum, Explained Sum. Retrieved from http://www.statisticshowto.com/residual-sum-squares/.

Rahayu Ahmad, Najeeb Kaid Nasser Al-Shorgani, Aidil Abdul Hamid, Wan Mohtar Wan Yusoff, Fauzi Daud1. 2013. Optimization of medium components using response surface methodology (RSM) for mycelium biomass and exopolysaccharide production by Lentinus squarrosulus. Advances in Bioscience and Biotechnology. 4: 1079-1085

R. K. Raja Ibrahim. 2012. Mid-Infrared Diagnostics of the Gas Phase in Non-Thermal Application. Unpublished PhD Thesis, University of Manchester Manchester, London.

Mohammed Evuti Abdullahi., Mohd Arifï¬n Abu Hassan., Zainura Zainon Noor., & R. K. Raja Ibrahim. 2015. Integrated Air Stripping And Non-Thermal Plasma System For The Treatment Of Volatile Organic Compounds From Wastewater: Statistical Optimization. Balaban Desalination Publications. 1944: 3980-3994

A. M. Vandenbroucke., R. Morent., N. D. De Geyter. & C. Leys. 2011. Non-Thermal Plasmas For Non-Catalytic And Catalytic VOC Abatement. J. Hazard. Mater. 195: 30-54.

H. L. Chen., H. M. Lee., S. H. Chen. & B. M. Chuang. 2008. Review of Packed-Bed Plasma Reactor For Ozone Generation And Air Pollution Control. Ind. Eng. Chem. Res. 47: 2122-2130.

Downloads

Published

2016-07-25

Issue

Section

Science and Engineering

How to Cite

OPTIMIZATION OF NON THERMAL PLASMA REACTOR PERFORMANCE FOR THE DECOMPOSITION OF XYLENE. (2016). Jurnal Teknologi, 78(8). https://doi.org/10.11113/jt.v78.7595