TECHNO-ECONOMIC AND ENVIRONMENTAL ASSESSMENT FOR A POLYGENERATION AND LOW EMISSION BIO-DME PRODUCTION FROM RICE STRAW IN VIETNAM

Authors

  • Huynh Quang Vinh Faculty of Chemical Engineering, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, Ho Chi Minh City, Vietnam
  • Duong Hoang Phi Yen Faculty of Chemical Engineering, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, Ho Chi Minh City, Vietnam
  • Le Minh Tan Vietnam National University Ho Chi Minh City (VNU-HCM), Linh Trung ward, Thu Duc District, Ho Chi Minh City, Viet Nam
  • Tran Tan Viet Faculty of Chemical Engineering, Ho Chi Minh City University of Technology (HCMUT), 268 Ly Thuong Kiet Street, Ho Chi Minh City, Vietnam

DOI:

https://doi.org/10.11113/aej.v15.22295

Keywords:

dimethyl ether, DME, biomass gasification, carbon capture, HYSYS

Abstract

The conversion of rice straw into energy such as dimethyl ether (DME) plays a significant role in driving and improving energy conversion efficiency due to its abundance and eco-friendliness”. Not only is an alternative for fossil fuels, rice straw-derived DME also affects the agriculture-based value chains. In this study, an upgrading DME production process was developed by HYSYS simulation for lower carbon dioxide (CO2) emission and then figured out its feasibility through techno-economic and environmental analysis. Technically, the modelled process generates around 2.3 ton/h of DME with a purity of 99.96% and an energy conversion efficiency (ηDME) of 75%. Otherwise, the additional presence of an off-gas absorber and CHP plant in the process reduced 84% of GHG emissions compared to the conventional process (0.21 kg CO2-eq/kg DME compared to 1.36 kg CO2-eq/kg DME, specifically). The CO2 capture also creates more products for this process and increases carbon efficiency to 94.6% with no CO content in fuel gas leaving the CHP section. The unit production cost (UPC) is estimated at 1,143 USD per ton of DME. These results created a net new positive contribution to commercial DME production, directing the majority of economic activity toward green and sustainable technology.

References

Hassan MK, Chowdhury R, Ghosh S, et al 2021. Energy and environmental impact assessment of Indian rice straw for the production of second-generation bioethanol. Sustainable Energy Technologies and Assessments 47: 101546

Kashanian M, Pishvaee MS, Sahebi H 2020. Sustainable biomass portfolio sourcing plan using multi-stage stochastic programming. Energy 204:117923

Silalertruksa T, Gheewala SH, Sagisaka M, Yamaguchi K 2013. Life cycle GHG analysis of rice straw bio-DME production and application in Thailand. Applied Energy. 112:560–567

Size XM 2021. Share&Covid-19 Impact Analysis. By Appl (Imaging Light Medical, Satell Electron others (including R&D), Reg Forecast 2020–2027 Available online https//www fortunebusinessinsights com/xenon-market-101965 (accessed 9 February 2024)

Albertazzi S, Basile F, Brandin J, et al 2008. Effect of fly ash and H2S on a Ni-based catalyst for the upgrading of a biomass-generated gas. Biomass and Bioenergy 32: 345–353

Alibaba.com 2022 Ash price. https://www.alibaba.com/product-detail/Price Cheap from Vietnam 2022 Rice_1700006381757.html?spm=a2700.galleryofferlist.normal_offer.d_title.22e36db62uEEn8 Alshbuki EH, Bey MM, Mohamed Aala 2020 Simulation Production of Dimethylether (DME) from Dehydration of Methanol Using Aspen Hysys. Scholars International Journal of Chemistry and Material Sciences 3(2): 13-18

Calvo LF, Gil MV, Otero M, et al 2012 Gasification of rice straw in a fluidized-bed gasifier for syngas application in close-coupled boiler-gasifier systems. Bioresource Technology. 109: 206–214

Clausen LR, Elmegaard B, Houbak N 2010 Technoeconomic analysis of a low CO2 emission dimethyl ether (DME) plant based on gasification of torrefied biomass. Energy 35: 4831–4842

Diep NQ, Sakanishi K, Nakagoshi N, et al 2015. Potential for rice straw ethanol production in the Mekong Delta, Vietnam. Renew energy 74: 456–463. https://doi.org/https://doi.org/10.1016/j.renene.2014.08.051

Do TN, Kim J (2020) Green C2-C4 hydrocarbon production through direct CO2 hydrogenation with renewable hydrogen: Process development and techno-economic analysis. Energy Convers Manag 214:112866

Farooqui A, Di Tomaso F, Bose A, et al 2019. Techno-economic and exergy analysis of polygeneration plant for power and DME production with the integration of chemical looping CO2/H2O splitting. Energy Conversion and Management. 186: 200–219

Gummert M, Hung N Van, Chivenge P, Douthwaite B 2020. Sustainable rice straw management. Springer Nature

Gupta MK, Song Q, Liu Z, et al 2021. Environment and economic burden of sustainable cooling/lubrication methods in machining of Inconel-800. Journal of Cleaner Production. 287: 125074

Haque N, Somerville M (2013) Techno-economic and environmental evaluation of biomass dryer. Procedia Engineering. 56: 650–655

Heryadi R, Uyun AS, Yandri E, et al 2019. Single stage dimethyl ether plant model based on gasification of palm empty fruit bunch. In: IOP Conference Series: Materials Science and Engineering. IOP Publishing, 12009

Heyne S, Harvey S 2014. Impact of choice of CO2 separation technology on thermo‐economic performance of Bio‐SNG production processes. International Journal of Energy Research. 38: 299–318

Le TM, Tran UPN, Duong YHP, et al 2022. Development of a paddy-based biorefinery approach toward improvement of biomass utilization for more bioproducts. Chemosphere 289: 133249

Lecksiwilai N, Gheewala SH, Sagisaka M, Yamaguchi K 2016. Net Energy Ratio and Life cycle greenhouse gases (GHG) assessment of bio-dimethyl ether (DME) produced from various agricultural residues in Thailand. Journal of Cleaner Production. 134: 523–531

Li G, Chang Y, Liu T, et al 2020 Hydrogen element flow and economic analyses of a coal direct chemical looping hydrogen generation process. Energy 206: 118243

Lima DFB, Zanella FA, Lenzi MK, Ndiaye PM 2012 Modeling and simulation of water gas shift reactor: an industrial case. Petrochemicals 10: 37181

Ma C, Pietrucci F, Andreoni W 2015. Capture and release of CO2 in monoethanolamine aqueous solutions: new insights from first-principles reaction dynamics. Journal of Chemical Theory and Computation. 11: 3189–3198

Mehrpooya M, Khalili M, Sharifzadeh MMM 2018. Model development and energy and exergy analysis of the biomass gasification process (Based on the various biomass sources). Renewable and Sustainable Energy Reviews. 91: 869–887

Mirmoshtaghi G, Skvaril J, Campana PE, et al 2016) The influence of different parameters on biomass gasification in circulating fluidized bed gasifiers. Energy Conversion and Management. 126: 110–123

Myhre G, Shindell D, Pongratz J 2014 Climate Change 2013 – The Physical Science Basis Working Group I Contribution to the Fifth Assessment Report of the Intergovernmental Panel on Climate Change. 8:659 – 740. Cambridge: Cambridge University Press

Okolie JA, Tabat ME, Gunes B, et al 2021. A techno-economic assessment of biomethane and bioethanol production from crude glycerol through integrated hydrothermal gasification, syngas fermentation and biomethanation. Energy Conversion and Management: X. 12: 100131

Parbowo HS, Ardy A, Susanto H 2019. Techno-economic analysis of Dimethyl Ether production using Oil Palm Empty Fruit Bunches as feedstock–a case study for Riau. In: IOP Conference Series: Materials Science and Engineering. IOP Publishing, 12060

Parvez AM, Mujtaba IM, Hall P, et al 2016. Synthesis of Bio‐Dimethyl Ether Based on Carbon Dioxide‐Enhanced Gasification of Biomass: Process Simulation Using Aspen Plus. Energy Technology. 4: 526–535

Peters MS, Timmerhaus KD 2018. Plant design and economics for chemical engineers. McGraw-Hill International

Peters MS, Timmerhaus KD, West RE 2003. Plant design and economics for chemical engineers. McGraw-hill New York

Rackley SA 2017 Carbon capture and storage. Butterworth-Heinemann

Rudy H, Aep Saepul U, Erkata Y, et al 2018. Palm empty fruit bunch gasification simulation in circulating fluidized bed gasifier. In: E3S Web of Conferences 67. EDP Sciences

Song D, Cho W, Lee G, et al 2008 Numerical analysis of a pilot-scale fixed-bed reactor for dimethyl ether (DME) synthesis. Industrial & Engineering Chemistry Research 47:4553–4559

Trippe F, Fröhling M, Schultmann F, et al 2013. Comprehensive techno-economic assessment of dimethyl ether (DME) synthesis and Fischer–Tropsch synthesis as alternative process steps within biomass-to-liquid production. Fuel Process Technology 106: 577–586

Vu TT, Lim Y-I, Song D, et al 2020. Techno-economic analysis of ultra-supercritical power plants using air-and oxy-combustion circulating fluidized bed with and without CO2 capture. Energy 194: 116855

Vu TT, Lim Y-I, Song D, et al 2021. Economic analysis of vanillin production from Kraft lignin using alkaline oxidation and regeneration. Biomass Convers Biorefinery 1–11

Zhang C, Jun K-W, Gao R, et al 2017. Carbon dioxide utilization in a gas-to-methanol process combined with CO2/Steam-mixed reforming: Techno-economic analysis. Fuel 190: 303–311

Zhu Z, Li Z, Liu C, et al 2020. Effects of dimethyl ether on soot formation in premixed laminar flame by laser induced incandescence method. Journal of Traffic and Transportation Engineering (English Edition) 7: 312–319

Downloads

Published

2025-02-28

Issue

Section

Articles

How to Cite

TECHNO-ECONOMIC AND ENVIRONMENTAL ASSESSMENT FOR A POLYGENERATION AND LOW EMISSION BIO-DME PRODUCTION FROM RICE STRAW IN VIETNAM. (2025). ASEAN Engineering Journal, 15(1), 65-76. https://doi.org/10.11113/aej.v15.22295