UTILIZATION OF MARBLE-CEMENT POWDER MODIFIED WITH GRAPHITE CARBON PARTICLES ON CONCRETE CONSTRUCTION FOR BUILDINGS IN SEASIDE AREAS
DOI:
https://doi.org/10.11113/jurnalteknologi.v85.20196Keywords:
Graphite carbon, marble powder, compressive strength, water curing, dry curingAbstract
This research aims to utilize marble industrial waste which is not utilized optimally and reduce air pollution as a result of cement production in cement industrial factories which produce a lot of CO2 emissions. The results of this research indicate that the use of 25 % Graphite Carbon Marble Particle Powder, to replace 25 % of the cement volume in making concrete with quality plans K-250 or fc’ 20,75 MPa. The results obtained are higher concrete quality than the quality of each concrete planned for the DCT type = 22,39 MPa > 20,75 MPa, DCL type = 22,76 MPa > 20,75 MPa, WCT type = 22,14 MPa > 20,75 MPa and WCL type = 22,89 MPa > 20,75 MPa. The compressive strength testing process is caried out based on ASTM C 39/C 39M – 05. Meanwhile for workability based on the results of the slump test, a slump value of 12 cm is obtained with the testing process referring to SNI 1972:2008 and ASTM C143/C143M-12.
References
Muhammad, Syarif, Victor, S., Wihardi, T. J. 2018. Characteristic of Compressive and Tensile Strength using the Organic Cement Compare with Portland Cement. Journal Case Studies in Construction Materials. e00172(9).
Doi.org/10.1016/j.cscm.2018.e00172.
Fran Edwin and Subar. 2016. Utilization of Marble and Limestone Wastes for Making the Eksposed Bricks based Synthetic Wollastonite. Jurnal Teknologi Mineral dan Batubara. 171-178.
. Dian Rokhmatika Siregar. 2017. Pengaruh Penambahan Limbah Marmer terhadap Potensial Swelling pada Tanah Lempung Ekspansif di Daerah Driyorejo. Jurnal Rekayasa Teknik Sipil. 3(3): 131-137
. Selma Kurniawati dan Anastasia Dewi Titisari. 2019. Rekomendasi Pemanfaatan Marmer Berdasarkan Karakteristiknya. Jurnal Pengabdian kepada Masyarakat. 5(2): 251-267
Doi:10.22146/jpkm.35963.
. Elia Hunggurami, Meriyanti FlowrindaLauata dan Sudiyo Utomo. 2013. Pemanfaatan Limbah Serbuk Batu Marmer Dari Batu Gunung Naitapan Kabupaten Timor Tengah Selatan Pada Campuran Paving Blok. Jurnal Teknik Sipil. II(1): 37-48.
. Candra Aditya, Dafid Irawan dan Silviana. 2018. Pasir dari Limbah Marmer Sebagai Bahan Stabilisasi pada Tanah Ekspansif. Prosiding Seminar Hasil Penelitian (SNP2M). 95-102.
. Susilowati. 2011. Pemanfaatan Serbuk Marmer Sebagai Bahan Pengganti Alternatif Semen Pada Campuran Beton Normal. Jurnal Arsitektur Universitas Bandar Lampung. 2(1).
. M. S. Kirgiz. 2016. Advancements in Mechanical and Physical Properties for Marble Powder–cement Composites Strengthened by Nanostructured Graphite Particles. Journal Mechanics of Materials. 92: 223-234
Doi.org/10.1016/j.mechmat.2015.09.013.
. Herda, Y., Wong Jee Khai, Mehmet Serkan Kırgız, Moncef L. Nehdi, Omrane Benjeddou, Blessen Skariah Thomas, Styliani Papatzani, Kishor Rambhad, Manoj, A. Kumbhalkar, Arash Karimipour. 2022. Transforming Conventional Construction Binders and Grouts into High-Performance Nanocarbon Binders and Grouts for Today’s Constructions. Journal Buildings. 12(7): 1041.
Doi.org/10.3390/buildings12071041.
. Arifin Everest, Mulia Pamadi, Andri Irfan Rifai. 2022. Analisa Pengaruh Penambahan Zat Karbon dalam Pembuatan Batako Konvensional. Journal of Civil Engineering and Planning. 3(1): 75-84
. Carlos Eduardo Tino Balestra, Lilyanne Rocha Garcez, Leandro Couto da Silva, Márcia Teresinha Veit, Eliziane Jubanski, Alberto Yoshihiro Nakano, Marina H. P., Ricardo Schneider, Miguel Angel Ramirez Gil. 2023. Contribution to Low-carbon Cement Studies: Effects of Silica Fume, Fly Ash, Sugarcane Bagasse Ash and Acai Stone Ash Incorporation in Quaternary Blended Limestone-calcined Clay Cement Concretes. Journal Environmental Development. 100792(45).
Doi.org/10.1016/j.envdev.2022.100792.
. Elli Mercy Julmile. 2023. Pengaruh Silica Fume dan Pecahan Batu Marmer sebagai Bahan Subtitusi pada Campuran Beton. Jurnal Civil Engineering Journal. 5(1).
Doi: https://doi.org/10.52722/pcej.v5i1.588.
. Bing Liu Songyuan Geng, Junpeng Ye, Xiaoyan Liu, Weixin Lin, Shihao Wu, Kai Qian. 2023. A Preliminary Study on Waste Marble Powder-based Alkali-activated Binders. Journal Construction and Building Materials. 378.
Doi.org/10.1016/j.conbuildmat.2023.131094.
. Kechkar Chiraz, Kherraf Leila, Houria Hebhoub, Assia Abdelouahid. 2022. The Comparative Study of the Performance of Concrete Made from Recycled Sand. The Civil Engineering Journal. 31(3): 415-426
Doi: 10.14311/CEJ.2022.03. 0031.
. Elyas Asadi Shamsabadi, Naeim Roshan, S. Ali Hadigheh, Moncef, L. Nehdi, Ali Khodabakhshian, Mansour Ghaleh novi. 2022. Machine Learning-based Compressive Strength Modelling of Concrete Incorporating Waste Marble Powder. Journal Construction and Building Materials. 126592(324).
Doi.org/10.1016/j. conbuildmat.2022.126592.
. America Society for Testing and Material, (ASTM). Designation C 39/C 39M – 05. Standard Test Method for Compressive Strength of Cylindrical Concrete Specimens. Annual book of ASTM Standards. 14 (01).
. SNI 7656: 2012. Tata Cara Pemilihan Campuran untuk Beton Normal, Beton Berat dan Beton Massa.
. SNI 1972: 2008. Cara Uji Slump Beton. Badan Standarisasi Nasional. ICS 91.100.30.
. American Society for Testing and Material, (ASTM). 2003. Designation C 143/C 143M – 03. Standard Test Method for Slump of Hydraulic-Cement Concrete. Annual Book of ASTM Standards. 04.02.
. Muhammad Syarif, Mehmet Serkan, Kırgız, André Gustavo de Sousa Galdino, M. Hesham El Naggar, Jahangir Mirza, Jamal Khatib, Said Kenai, Moncef Nehdi, John Kinuthia, Anwar Khitab, Carlos Thomas, Ravindran Gobinath, Muhammad Irfan Ul Hassan, Yan Kai Wu, Ahmed Ashteyat, Ahmed Soliman, Khairunisa Muthusamy, Thaarrini Janardhanan, Trinity Ama Tagbor, Tuan Anh Nguyen Chandra Sekhar Tiwary. 2021. Development and Assessment of Cement and Concrete Made of the Burning of Quinary by Product. Journal of Materials Research and Technology. 15: 3708-3721.
Doi.org/10.1016/j.jmrt.2021.09.140.
Downloads
Published
Issue
Section
License
Copyright of articles that appear in Jurnal Teknologi belongs exclusively to Penerbit Universiti Teknologi Malaysia (Penerbit UTM Press). This copyright covers the rights to reproduce the article, including reprints, electronic reproductions, or any other reproductions of similar nature.
